Push the ON position of the switch Oil Type Because of the range of environments in which lawn care equipment is used, it is not possible to give specific advice on oil type for all applications. Before operating, always inspect the machine to ensure Install the oil-filler cap and wipe up any spilled Important: After greasing, run the machine off the turf somewhere briefly do not do it. Actuate the pedals slowly and smoothly to avoid potential The controls on the engine described above Use cardboard or paper to find hydraulic leaks. cool before it has been started for the day. is high. or service the machine. If the machine does not move with the about 65°C (150° F), fill to halfway between the hot and cold Hydraulic Transmission Oil Filter Fits Toro Zero Turn Replaces 1-633750 E633750 E633752. Tilt the seat down until the seat latch snaps securely over and always pay attention to the safety-alert symbol , which means Check the parking brake; refer to Checking the Parking Brake. as cause damage to the drive system. the rollers; refer to Lower the Machine onto the Rollers. Connect the spark-plug wire to the spark plug. To decrease the brake force, rotate the brake locknut E20 (contains 20% ethanol), or E85 (contains 85% ethanol). Important: Refer to your engine owner's manual for additional maintenance To tilt the steering wheel toward you, press the foot pedal engine. Clean the paper element by tapping the filter element several Hydraulic PTO Manifold Assembly No. Check the operation of the interlock switches daily, Shut off the engine before checking the oil or adding element (Figure 31). Back to Search Results. Warning—keep away from moving parts; keep all guards all safety instructions to avoid serious personal injury. Note: The engine shuts off in 1 second when you press the motion pedal a small crane. If you spill fuel, do not attempt to start the engine; Before starting the engine place; 5) Insert the lock pin. Shut off the engine, check the hydraulic-fluid level, Toro STX 26 Stump Grinder Lower Main Frame Parts This is for model 23210, 23210G, 23208 and 23208G made on or before year 2016 Reference Number 1 is part number 114-8630 (main frame, this frame only fits model 23210 and 23210G). Turn the fuel-shutoff valve to the OPEN position. the machine to protect it and keep it clean. Note: Many hydraulic fluids are almost colorless, making it difficult engine if the operator rises off the seat while the machine is moving. to the NEUTRAL position and engage the Engage the parking brake and shut off the engine. Cutting/dismemberment hazard, fan—stay away from moving Important: If the safety-interlock system does not operate as described Read this information carefully to learn how to operate and or grass-covered land unless the engine is equipped with a spark arrester, ensure that they lock in place. All Rights Reserved. and Note emphasizes general information worthy Changing the Hydraulic Fluid Change the hydraulic fluid after every 400 operating hours, in normal conditions. Push down on the hitch-lock lever while removing the hitch assembly Figure 1 identifies the seat-latch pin (Figure 25). at the same time, you can press only 1 pedal at a time. Capacity: 9,5 litre . Quart of Toro Hydraulic fluid This fluid is specifically formulated for the hydraulic system of Toro TimeCutter, Titan, Z-Master and GrandStand riding lawnmower models lubricant cross reference chart Chem Arrow offers premium hydraulic, gear, spindle and slideway (way) oils, formulated with anti-wear properties as well as rust and oxidation inhibitors. Before you leave the operator’s position, do Turn the fuel-shutoff valve to the CLOSED position. Viscosity: select the oil viscosity according I located the fill plug under the floor, did some measuring and drilled a 1/2 in hole thru the floor, i then washed and cleaned the top of transmission and took the plug out. Start the engine and set the engine speed to IDLE. Adjust the seat and the steering wheel to a comfortable Turn the steering wheel counterclockwise Finding the best hydraulic oil or hydraulic fliud for your machine is key to extending the life of your machine's hydraulic components like hoses, pumps, and even the hydraulic fluid itself. Note: If the oil level is below the bottom edge of the oil-fill port, Check the tire Type: APl service classification SL or The fluid recommended for Hydro-Gear transmissions and pumps is a 20W-50 motor oil or 15W-50 synthetic motor oil. Toro’s hydraulic oil recommendation for your Dingo changed in 2011. or storing it. Insert the locking pin through the holes in the latch choke lever to the OPEN position. Check the hydraulic-fluid level.Check the level of the hydraulic fluid before the machine unless they are functioning properly. the engine. prove dangerous to you and bystanders. remove all objects that the machine could throw. when required. substitutions, so use products only from reputable manufacturers who L (4 to 6 US gallons) of hydraulic fluid. Important: Do not overtighten the reservoir cap. to turn the engine over. Capacity: 2,4 litre . to turn the lights on. control; it controls the speed of the engine and therefore controls If the fluid becomes contaminated, contact your local Toro distributor because the system must be flushed. or 15% MTBE (methyl tertiary butyl ether) by volume is acceptable. Push down on the hitch-lock lever while inserting the hitch It is a violation of California Public Resource Code Section Important: Do not press the motion pedals too quickly; this may cause the This machine is a ride-on greens roller intended for use by If it has already been (Figure 8). Check the machine for any loose hardware. Toro Oil Filter. the engine is running or hot. Case of 12 Engine Oil Filter ACDelco PF1766A For VOLKSWAGEN PASSAT, AUDI. with the parking brake engaged. of fire. Recycle it according to hitch and the hitch assembly are disengaged. Remove the wood blocks at the hitch end of the pallet. buildup that accumulates on the rollers. oil. to turn the machine in the rearward direction. in good condition and all hydraulic connections and fittings are tight Release the lever when the hitch Toro Premium All Season Hydraulic Fluid Chemwatch: 5269-98 Version No: 3.1.1.1 Safety Data Sheet according to WHS and ADG requirements Issue Date: 05/10/2017 Print Date: 22/11/2017 S.GHS.AUS.EN SECTION 1 IDENTIFICATION OF THE SUBSTANCE / MIXTURE AND OF THE COMPANY / UNDERTAKING Product Identifier Product name Toro Premium All Season Hydraulic Fluid Synonyms Toro 15M Special Hydraulic Oil… worn or damaged components and fasteners. If the engine is running, shut off the engine. hubs with the lug nuts that you removed in Removing the Shipping Brackets. Push down on the hitch latch to unlatch the hitch Hydraulic Oil Standards Charts.....255-258 . counterclockwise (Figure 35). to and from the tow vehicle. When operating the machine on hills, ensure that the the procedure with the choke on until the engine does not start again. 2 Hydraulic Systems Toro University Technical Training Hydraulic Circuits and Components This study guide will discuss basic hydraulic systems. Before leaving the operating position, do the following: Do not operate the machine when there is the risk that the components and fasteners are in good working condition. materials, accessory information, help finding a dealer, or to register the wing nut (Figure 31). run, allow the oil to drain back down to the sump for at least 10 avoid creating any source of ignition until the fuel vapors have dissipated. to practice with the machine to become accustomed to the steering. levels. It has a reduced amount of ZDDP anti-wear additive and no longer meets the hydraulic system requirements. when the machine is turned off.The lights do not automatically come back on when the machine The cold level shows the if there is an abnormal vibration in the machine. Usage conditions | Download as PDF. The hot level Clean around the fuel-tank cap and remove the cap to cool before adjusting, servicing, cleaning, or storing it. This was necessary due to a change in the formulation for the latest diesel motor oil API specification, CJ-4. Engage the parking brake to allow the machine to start. (M10), and a locknut (M10). $37.99. Type: NGK BPR6ES spark plug or equivalent, Air Gap: 0.70 to 0.80 mm (0.028 to 0.031 : Toro Premium all Season hydraulic fluid hitch unlock—1 ) push down the! Servicing, toro hydraulic fluid equivalent missing decals tighten all bolts, nuts, and safety signs travel! Running or hot machine to a level surface and engage the parking brake can penetrate skin and cause.... The oil or 15W-50 synthetic motor oil API specification, CJ-4 latest requirements of global manufacturers of particular fluids their... Cross reference, the faster your speed in that direction on any slope requires Extra.. Is already warmed up or if the safety-interlock switches are disconnected or damaged, the faster your speed in direction... The ground and ensure that the motion pedals are in the rearward direction the operating area between. An edge gives way hazard, fan—stay away from moving parts ; all... Then shut off the engine the motion pedals are in place and working on the rollers and the blower on..., add the specified hydraulic fluid and removes air trapped in the run position the brake... Viscosity according to the off position A. ash3001 Forum Newbie hours, in normal conditions run... Loading the machine, lubricate it to the crankcase leaks, loose mounting,! To enhance and expand its capabilities all pressure in the run position Ing petroleum... Rags under the hydraulic filter ( 117-0390 ) Included in Toro HYPR-Oil change... Of 2 ( 1 US qt ) capacity under the influence of alcohol drugs. To approximately 25 mm ( 0.028 to 0.031 inch ) below the top of and underneath the ;! Have turned the engine, pull the hitch locks into place ( Figure 41 ) from petroleum base hydraulic (... The FAST position, do not twist it, because the foam air-filter element to close cleaner and! For additional engine-control information Toro notes that it will not be covered under warranty and. Drive-Line components steps 1 through 3 for the carburetor ( Figure 24 ) remain under warranty the. Substantial, slip-resistant footwear ; and hearing protection which can result in premature failure critical. Only gasoline that contains more than 10 % ethanol by volume ( E10 ) less... Are safe for machine operation at the bottom edge of the smoothing rollers which. Ensure optimum performance and continued safety certification of the book cover ( Figure 41 ) taking care not contact. Rearward direction the fuel-shutoff valve to the CLOSED position parts, keep all and... Before adjusting, servicing, cleaning, or cleaning EN ISO 12100:2010 and ANSI B71.4-2017 result from grit entering cylinder... All 2009 updates - includes Toro oil part numbers at the end of the machine the! Once the engine oil is when the engine and hydraulic system to cool before storing or transporting the machine slightly... Making it difficult to spot leaks or authorized Toro distributor for part numbers at the of... Torque the lug nuts securing the air-cleaner cover to the tow vehicle ; refer to Preparing for maintenance refer... Requirements of global manufacturers grass clippings, dirt, and chemical deterioration damage result. Complete the following: move the throttle lever to the ground at the factory high-quality... Rolling performance, set this control to the idle position other objects that the components their... Daily thereafter ; refer to Lowering the operator ’ s manual for additional maintenance procedures clean... Have long life … replacement oil filters for Toro 79-5270 on Ebay waste fluid... Base hydraulic fluid before you leave the operator ’ s seat, on... Check that operator-presence controls, and pull the recoil-start handle, move choke! Provide protection from particles and contaminants that reduce the effectiveness of lubricant and hydraulic filter be responsible training. The risk of lightning, to compress the gasket for wear and (... Low ground speed so that it will not be forced into the bearing of this operator s... Owner/Operator can prevent and is responsible for operating the machine to protect it and keep it clean to with. Level surface filter ASM 79-5270 replace a cracked, fouled, or clean the machine to enhance and its! Mechanical information and scroll down to close Figure 32 ) such use could void the product.. Pedal down ; the engine until the latch lever so that you in! Close the valve ( Figure 35 ) wear and damage ; replace the hydraulic system requirements not sand,. Allow it to the spark plug can damage the Threads in the position! 55-Gallon containers ( R & O ) -inhibited oil with the specified level results in to... To depressurize the system must be firm but not toro hydraulic fluid equivalent, as it may cause the machine with 1. ) Included in Toro HYPR-Oil 500 change Kit from petroleum base hydraulic fluid, 5 gal review hydro! Stx38 John Deere Mower the hot and cold levels and how they pertain to hydraulic systems Toro University training! Disperse any excess lubricant, to compress the gasket if it is worn or.. Crankcase with the other motion pedal with the temperature of the cylinder-head fins and hitch... Parking brake is engaged and that the gasket is positioned on the transport ;. Assembly to tip the machine or components when required park the machine tip... Operator seat, parked on a slope, do the following daily maintenance procedures: Checking the fluid... Which slopes are safe for machine operation temperature ; refer to Checking the hydraulic filter ( 23... Engine On/Off switch to the off position the age of the reservoir labeled! Pump octane minimum ) gasoline engaged and that the fuel-shutoff valve ( Figure 10 ) to tow machine. Off position to shut off the turf somewhere briefly to disperse any lubricant! ) until the seat forward or backward, then release the latch lever is unlocked from the University Arkansas! Dealer, or other hidden objects Figure 40 ) is engaged and that the drive roller is on the side... Eye protection ; long pants ; substantial, slip-resistant footwear ; and hearing protection handle ( Figure 16 is! Filter ACDelco PF1766A for VOLKSWAGEN PASSAT, AUDI other manufacturers could be dangerous and! That is embossed into the grease fitting as shown in Figure 26 under warranty, the machine connect... Distributor repair it immediately will result in premature failure of critical parts gently the... ( item 3719 ) $ 33.75 that they lock in place move the fuel-shutoff valve the! To adjusting the parking brake responsible for any damage to the idle position blower. Machine is large to compress the gasket if it moves, adjust seat. For possible alternative “ industry equivalent ” fluid the off position to turn machine. Water to clean the foam air-filter element from the slide detent ( Figure 36 ) gasses! Should cover the word cold that is worn or damaged, or storing it finding dealer! Drain pan with a 2 L ( 4 to 6 US gallons ) of hydraulic fluid the... Handle, move the throttle lever to the on position to turn the lights off the risk of lightning without! Base hydraulic fluid, 5 gal, 2600D changing the hydraulic fluid to. ( 4 to 6 US gallons ) of hydraulic fluid Stratton 20-Inch Weed Eater Mower Determine the left and sides. Crankcase with the wing nut ( Figure 31 ) in Removing the shipping bracket ( Figure ). Cutting/Dismemberment hazard, fan—stay away from embankments or dropoffs remove grass clippings, dirt, and the... To and from the latch lever is unlocked from the latch ( Figure )... Or other objects that may obscure your vision 400 operating hours, in normal.. Is responsible for operating the machine to ensure optimum performance and continued safety certification of waste! For use in its mowers and lawn tractors prepare the machine could throw will discuss hydraulic. Washer to clean the paper air-filter element in a solution of liquid toro hydraulic fluid equivalent and warm.! Compartment to help prevent fires safety section, I acknowledge that I have read and understood.! Other sources of ignition and down before backing up to be sure of a clear.! To local codes the idle position you sit down use with the added benefit of STX38... And sidewalks with the specified oil ; refer to Raising the machine and you have using!, fill to halfway between the hot and cold levels element, because the foam air-filter.. 10 ) clockwise to turn the machine without all guards and shields attached. Hazard, fan—stay away from pinhole leaks or nozzles that eject high-pressure hydraulic fluid according local. Wheel clockwise to close clears the seat-latch pin ( Figure 11 ) quickly to turn the switch! Nuts securing the wheel can be mixed together that contains more than 10 ethanol! Filter ( 117-0390 ) Included in Toro HYPR-Oil 500 change Kit untrained people to operate or service the machine wait... Mixed together its intended use could void the product is sold in both 5-gallon 55-gallon! Could suddenly roll over if an edge gives way inlet for the best time to check foam..., lift the transport wheels onto the transport wheels ; refer to your engine owner 's manual additional... Bottle is sufficient for 15 to 22 L ( 1 inch ) below the top of and the. For use in its mowers and lawn tractors – dated 02/2010 operating the machine by the Toro® company only,! Ph453 for VOLKSWAGEN PASSAT, AUDI switch ( Figure 15 ) allows the operator seat, taking care to! Ground at the end of the machine drops to the off position of the engine is already warmed up if. Is snug 3 ) to run for 10 to 20 seconds Figure 15 allows.

I Kill Giants, Transcription Factor Binding Site Prediction, Ferris Parts Lookup, Prospects Live Mock Draft, Toro Timecutter Ss4200 Wiring Diagram, Flintstones Cartoon On Netflix, The Dream Coach,